HVAC
Chapter 10 of the factory service manual — 194 procedures.
Procedures in this chapter
Section titled “Procedures in this chapter”- A_C Compressor Controls (L84_L87)
- A_C Compressor Controls (LM2)
- A_C Diagnostics Chart
- Actuator Recalibration
- Actuators
- Adhesives, Fluids, Lubricants, and Sealers
- Afterblow Configuration
- Air Conditioning (A_C) System Performance Test (L84, L87)
- Air Conditioning (A_C) System Performance Test (LM2)
- Air Conditioning Clutch Drive Plate Adjustment (L84_L87)
- Air Conditioning Clutch Drive Plate Adjustment (LM2)
- Air Conditioning Clutch Replacement (L84, L87)
- Air Conditioning Clutch Replacement (LM2)
- Air Conditioning Compressor and Condenser Hose Replacement (L84_L87)
- Air Conditioning Compressor and Condenser Hose Replacement (LM2, 2WD)
- Air Conditioning Compressor and Condenser Hose Replacement (LM2, 4WD)
- Air Conditioning Compressor Malfunction
- Air Conditioning Compressor Oil Balancing
- Air Conditioning Compressor Oil Diagnosis
- Air Conditioning Compressor Replacement (L84_L87)
- Air Conditioning Compressor Replacement (LM2, 2WD)
- Air Conditioning Compressor Replacement (LM2, 4WD)
- Air Conditioning Condenser and Evaporator Hose Replacement (L84, L87)
- Air Conditioning Condenser and Evaporator Hose Replacement (LM2)
- Air Conditioning Condenser Replacement (L84_L87)
- Air Conditioning Condenser Replacement (LM2)
- Air Conditioning Evaporator Air Temperature Sensor Replacement
- Air Conditioning Evaporator Replacement
- Air Conditioning Evaporator Thermal Expansion Valve Replacement
- Air Conditioning O-Ring Seal Replacement
- Air Conditioning Receiver and Dehydrator Replacement (L84_L87)
- Air Conditioning Receiver and Dehydrator Replacement (LM2)
- Air Conditioning Refrigerant Filter Replacement (C69)
- Air Conditioning Refrigerant Heat Exchanger Replacement (L84_L87 with C69)
- Air Conditioning Refrigerant Heat Exchanger Replacement (L84_L87 without C69)
- Air Conditioning Refrigerant Heat Exchanger Replacement (LM2 with C69)
- Air Conditioning Refrigerant Heat Exchanger Replacement (LM2 without C69)
- Air Conditioning Refrigerant Pressure Sensor Replacement (L84_L87)
- Air Conditioning Refrigerant Pressure Sensor Replacement (LM2)
- Air Conditioning Refrigerant Service Valve Core Replacement
- Air Conditioning System Seal Replacement
- Air Heater (C3A)
- Air Inlet Deflector Water Deflector Replacement
- Air Inlet Housing Replacement
- Air Inlet Valve Actuator Replacement
- Ambient Light_Sunload Sensor, Windshield Moisture Sensor and A_C Evaporator Temperature Sensor
- Approximate Fluid Capacities
- Automatic HVAC Description and Operation
- Auxiliary Blower Motor Malfunction
- Auxiliary Heater and Air Conditioning Wiring Harness Replacement (C69, with 9C1)
- Auxiliary Heater and Air Conditioning Wiring Harness Replacement (C69, without 9C1)
- Auxiliary HVAC Air Speed, Delivery, and Temperature (C69)
- Auxiliary HVAC Controls Power, Ground, and Serial Data (C69)
- Blower Motor (00H)
- Blower Motor (-00H)
- Blower Motor Control Module Replacement (C69, with 9C1)
- Blower Motor Control Module Replacement (C69, without 9C1)
- Blower Motor Malfunction
- Blower Motor Replacement
- Defrosting Insufficient (L82 L84 L87)
- Defrosting Insufficient (LM2)
- DTC B2A01-B2A05 (L84, L87)
- DTC B2A01-B2A05 (LM2)
- DTC B2A1A-B2A1D (L84, L87)
- DTC B2A1A-B2A1D (LM2)
- DTC B2A1E-B2A21 (L84, L87)
- DTC B2A1E-B2A21 (LM2)
- DTC B2A3E-B2A41 (L84, L87)
- DTC B2A3E-B2A41 (LM2)
- DTC B2A6B-B2A6E (L84, L87)
- DTC B2A6B-B2A6E (LM2)
- DTC B2A6F-B2A72
- DTC B2A7B-B2A7E
- DTC B2A8B-B2A8E (L84, L87)
- DTC B2A8B-B2A8E (LM2)
- DTC B2A8F-B2A92
- DTC B2A9B-B2A9E
- DTC B2A16-B2A19 (L84, L87)
- DTC B2A16-B2A19 (LM2)
- DTC B2A36-B2A39 (L84, L87)
- DTC B2A36-B2A39 (LM2)
- DTC B2A42-B2A45 (L84, L87)
- DTC B2A42-B2A45 (LM2)
- DTC B2A67-B2A6A (L84, L87)
- DTC B2A67-B2A6A (LM2)
- DTC B2A76
- DTC B2A86
- DTC B2A87-B2A8A (L84, L87)
- DTC B2A87-B2A8A (LM2)
- DTC B2A93-B2A96 (L84, L87)
- DTC B2A93-B2A96 (LM2)
- DTC B2A97-B2A9A (L84, L87)
- DTC B2A97-B2A9A (LM2)
- DTC B2AEF or B2AF0-B2AF4
- DTC B2AF5-B2AFA
- DTC B2AFB-B2AFE
- DTC B2AFF-B2B01 (L84, L87)
- DTC B2AFF-B2B01 (LM2)
- DTC B2B02, B2B03, B2B0B, or B2B0C (L84, L87)
- DTC B2B02, B2B03, B2B0B, or B2B0C (LM2)
- DTC B2B05 or B2B28-B2B2A (L84, L87)
- DTC B2B05 or B2B28-B2B2A (LM2)
- DTC B2B06 or B2B2B-B2B2D (L84, L87)
- DTC B2B06 or B2B2B-B2B2D (LM2)
- DTC B2B07 or B2B22-B2B24
- DTC B2B09 or B2B2E-B2B30
- DTC B2B16
- DTC B2B95-B2B97 (L84, L87)
- DTC B2B95-B2B97 (LM2)
- DTC B2B98-B2B9A (L84, L87)
- DTC B2B98-B2B9A (LM2)
- DTC B10FA or B1141
- DTC P18F2
- DTC P0532 or P0533
- DTC P0535, P0537, P0538, or P153B (L84, L87)
- DTC P0535, P0537, P0538, or P153B (LM2)
- DTC P0645, P0646, or P0647
- Fastener Specifications (1)
- Fastener Specifications
- Floor Front Air Outlet Duct Replacement - Left Side
- Floor Front Air Outlet Duct Replacement - Right Side
- Floor Rear Air Outlet Duct Adapter Replacement - Left Side
- Floor Rear Air Outlet Duct Replacement - Left Side (9C1, BG9, with Front Floor Console)
- Floor Rear Air Outlet Duct Replacement - Left Side (9C1, BG9, without Front Floor Console)
- Floor Rear Air Outlet Duct Replacement - Left Side (without 9C1, BG9)
- Floor Rear Air Outlet Duct Replacement - Right Side (9C1, BG9, with Front Floor Console)
- Floor Rear Air Outlet Duct Replacement - Right Side (9C1, BG9, without Front Floor Console)
- Floor Rear Air Outlet Duct Replacement - Right Side (without 9C1, BG9)
- Flushing
- Front Floor Console Auxiliary Cooling Duct Replacement (with UQA)
- Front Floor Console Auxiliary Cooling Duct Replacement (without UQA)
- Front Floor Console Auxiliary Cooling Intermediate Duct Replacement (K4C)
- Handling of Refrigerant Lines and Fittings
- Heater and Air Conditioning Auxiliary Control Replacement (with 9C1)
- Heater and Air Conditioning Auxiliary Control Replacement (without 9C1)
- Heater and Air Conditioning Evaporator and Blower Lower Case Replacement (C69)
- Heater and Air Conditioning Evaporator and Blower Module Removal and Installation
- Heater and Air Conditioning Evaporator and Blower Upper Case Replacement (C69)
- Heater and Air Conditioning Evaporator Case Replacement - Upper
- Heater and Air Conditioning Evaporator Case Replacement (Distributor)
- Heater and Air Conditioning Evaporator Module Cover Replacement (Air Flow Distributor)
- Heater and Air Conditioning Evaporator Module Cover Replacement (Evaporator Pipe)
- Heater and Air Conditioning User Interface Control Replacement (with D07)
- Heater and Air Conditioning User Interface Control Replacement (with DCH)
- Heater and Air Conditioning User Interface Control Replacement (without DCH, D07)
- Heater Coolant Pump Replacement (L84, L87)
- Heater Coolant Pump Replacement (LM2)
- Heater Inlet Hose Replacement (L84, L87)
- Heater Inlet Hose Replacement (LM2)
- Heater Outlet Hose Replacement (L84, L87)
- Heater Outlet Hose Replacement (LM2)
- Heater Replacement
- Heater Wiring Harness Replacement
- Heating and Air Conditioning System Description and Operation
- Heating Performance Diagnostic
- HVAC Component Replacement Reference
- HVAC Controls
- HVAC Schematics
- HVAC System Malfunction
- Instrument Panel Center Air Outlet Duct Replacement - Left Side
- Instrument Panel Center Air Outlet Duct Replacement - Right Side
- Instrument Panel Center Air Outlet Replacement
- Instrument Panel Outer Air Outlet Duct Replacement - Left Side (with UV6)
- Instrument Panel Outer Air Outlet Duct Replacement - Left Side (without UV6)
- Instrument Panel Outer Air Outlet Duct Replacement - Right Side
- Instrument Panel Outer Air Outlet Replacement - Left Side
- Instrument Panel Outer Air Outlet Replacement - Right Side
- Leak Testing
- Mode Control Cam Replacement
- Mode Valve Actuator Replacement
- Noise Diagnosis - Air Conditioning (A_C) System
- Noise Diagnosis - Auxiliary Blower Motor
- Noise Diagnosis - Blower Motor
- Noise Diagnosis - HVAC Module
- Odor Correction
- Odor Diagnosis
- Passenger Compartment Air Filter Replacement
- Rear Programmable Mode Valve Actuator Replacement (with C69, 9C1)
- Rear Programmable Mode Valve Actuator Replacement (with C69, without 9C1)
- Rear Programmable Temperature Valve Actuator Replacement (with C69, 9C1)
- Rear Programmable Temperature Valve Actuator Replacement (with C69, without 9C1)
- Refrigerant Label Symbols
- Refrigerant Recovery and Recharging
- Side Window Defogger Outlet Duct Replacement - Left Side (with UV6)
- Side Window Defogger Outlet Duct Replacement - Left Side (without UV6)
- Side Window Defogger Outlet Duct Replacement - Right Side
- Special Tools
- Sun Load and Ambient Light and Security Indicator Sensor Replacement
- Symptoms - Heating, Ventilation, and Air Conditioning
- Symptoms - HVAC Systems - Automatic
- Temperature Valve Actuator Replacement - Left Side
- Temperature Valve Actuator Replacement - Right Side
- Windshield Defroster Outlet Duct Replacement
- Windshield Outside Moisture_Ambient Light and Humidity Sensor Replacement