DTC P20E8 or P20E9
Engine Controls and Fuel - 3.0L LM2 Diesel | Diagnostic Information and Procedures | Document ID: 5507568 Diagnostic Instructions Perform the Diagnostic System Check prior to using this diagnostic procedure: Diagnostic System Check - Vehicle Review the description of Strategy Based Diagnosis: Strategy Based Diagnosis An overview of each diagnostic category can be found here: Diagnostic Procedure Instructions DTC Descriptor DTC P20E8 Reductant Low Pressure DTC P20E9 Reductant High Pressure Circuit/System Description For an overview of the component/system, refer to: Exhaust Aftertreatment System Description Conditions for Running the DTC DTC P10DA, P10DB, P10F4, P20FF, U2412, U2626 = Not set DTCs related to the following system/component = Not Set – G33 Reductant Pump – B194 Reductant Pressure Sensor Engine = Running Ignition and Start Switch Signal = Greater than 11 V Reductant Fluid Reservoir = Not Frozen Frequency the DTC runs = Continuously — After the running conditions are met Conditions for Setting the DTC P20E8 Reductant Pressure = Less than a predefined threshold — For greater than 30 s P20E9 Reductant Pressure = Greater than a predefined threshold — For greater than 4 s Actions Taken When the DTC Sets DTCs listed in the DTC Descriptor category = Type A DTC Conditions for Clearing the DTC DTCs listed in the DTC Descriptor category = Type A DTC Reference Information DTC Type Reference Powertrain Diagnostic Trouble Code (DTC) Type Definitions Scan Tool Reference Control Module References Circuit/System Verification
- Ignition » On / Vehicle » In Service Mode
- Verify no other DTCs are set. ⇒ If other DTCs are set ⇒ Refer to: Diagnostic Trouble Code (DTC) List - Vehicle ⇓ If no other DTCs are set
- Verify the scan tool parameter: Reductant Level = Greater than 20% ⇒ If not the specified state Fill the reductant tank to a minimum of 4 L. ⇓ If the specified state
- Perform the scan tool control function: Reductant System Leak Test Verify the scan tool parameter: Reductant Pressure = 450 to 550 kPa (65 to 80 PSI) ⇒ If not between 450 and 550 kPa (65 and 80 PSI) Refer to: Circuit/System Testing ⇓ If between 450 and 550 kPa (65 and 80 PSI)
- Operate the vehicle within the Conditions for Running the DTC. You may also operate the vehicle within the conditions that you observed from the Freeze Frame/Failure Records data. ⇒ If the DTC sets Refer to: Circuit/System Testing ⇓ If the DTC is not set
- All OK. Circuit/System Testing
- Verify the condition does not exist: Contamination — Emission Reduction Fluid » Refer to: Contaminants-in-Diesel Exhaust Fluid Diagnosis ⇒ If a condition exists Repair or replace as necessary ⇓ If no condition exists
- Perform the scan tool control function: Reductant System Leak Test Verify the condition does not exist: Hoses / Lines — Leaking ⇒ If a condition exists Repair or replace as necessary ⇓ If no condition exists
- Remove the component: Q61 Reductant Injector — Leave the reductant line and the electrical connector connected.
- Place the injector into a suitable container.
- Perform the scan tool control function: Reductant System Leak Test Verify the condition does not exist: Reductant Injector — Leaking ⇒ If a condition exists Replace the component: Q61 Reductant Injector ⇓ If no condition exists
- Perform the scan tool control function: Reductant System Leak Test Verify the scan tool parameter: Reductant Pressure = 450 to 550 kPa (65 to 80 PSI) ⇒ If not between 450 and 550 kPa (65 and 80 PSI) Replace the component: A38 Reductant Pump and Sensor Assembly ⇓ If between 450 and 550 kPa (65 and 80 PSI)
- All OK. Repair Instructions Perform the Diagnostic Repair Verification after completing the repair: Diagnostic Repair Verification Reductant Fluid Injector Replacement — Q61 Reductant Injector Emission Reduction Fluid Tank Replacement — A38 Reductant Pump and Sensor Assembly For control module replacement, programming, and setup refer to: Control Module References Additional Procedures